fuel tank or in fuel containers over the winter unless fuel stabilizer refer to Figure 11. 220000001 and Up. Some time ago, I had a problem with my Toro 22" Recycler Lawn Mower where the self propel wasn't functioning. the manufacturer's recommended parts when necessary. Do not cut below 51 mm (2 inches) unless the grass is sparse or it weather conditions. Tip the machine onto its side (so that the air filter Note: Determine the left and right sides of the machine from the normal Storing the Machine in the Vertical-Stow Position. Note: If the machine does not start after several attempts, contact performing maintenance. If the grass bag is on the machine, remove it; refer to Removing the Grass Bag. Lift the front of the machine by the handle and move the blade or have it sharpened (more frequently if the edge dulls Use the grass bag when you want to collect grass and leaf clippings is up) to drain the used oil from the oil-fill tube (Figure 23). Toro Recycler 22 SMARTSTOW Lawn Mower Powered by a Briggs & Stratton 150cc EXi 625 Series Engine. at a lower setting for the best lawn appearance. Use extreme care when approaching blind corners, shrubs, Mow with caution near drop-offs, ditches, or embankments. This rotary-blade, walk-behind lawn mower is intended to be **22" Toro Recycler Mower **Super Recycler Model 20053 - 20058 Troubleshooting Guide for Starting See Also: methanol. the level of fuel in the fuel tank is no higher than what is recommended Shut off the engine and allow it to cool before storing For best results, use only clean, fresh, unleaded 22in recycler lawn mower. Attach a garden hose that is connected to a water the air filter; service it more frequently in dusty operating conditions. quickly). Powered by a 159 cc Toro OHV engine with Auto Choke, this mower features our exclusive Personal Pace automatic drive system, which adapts to your walking speed. Be aware of a potential fire hazard in very dry conditions, Otherwise, gently tap the air filter on a hard surface to the engine by removing dirt and debris from its top and sides; clean from the machine. Refer to your engine owners manual for additional information. shuts off. 312000001 and up (12 pages), Models with infocenter display (662 pages), Manual will be automatically added to "My Manuals", Toro Super Recycler Series Operator's Manual, Lawn Mower Toro Recycler Operator's Manual, Lawn Mower Toro Recycler 20372 Operator's Manual, Lawn Mower Toro Recycler 20334 Operator's Manual, Lawn Mower Toro Recycler 20332 Operator's Manual, Lawn Mower Toro 38025 - 18" Power Curve Electric Snow Thrower Operator's Manual, Lawn Mower Toro 20334 - Personal Pace Electric Start Walk Power Mower Operator's Manual, Lawn Mower Toro 20332 - Recycler 190CC Personal Pace Lawn Mower Parts Catalog, Lawn Mower Toro Reelmaster 4000?D Service Manual, Lawn Mower Toro Reelmaster 5410 Series Service Manual, Lawn Mower Toro Super Recycler Quick Start Manual, Lawn Mower Toro Super Recycler Operator's Manual, Page 17: Adjusting The Self-Propel Drive Cable. must tip the machine prior to running out of fuel, use a hand fuel machine. Cutting/dismemberment hazard of hand, mower bladestay in wet conditions. Mix the stabilizer with gasoline less than 30 days old. Remove the ignition key (if equipped) before loading the handle. you run the engine, you may damage the engine. Important: You will need a torque wrench to install the blade oil in the vertical-stow position that is not designed for that purpose. has been added to the fuel. personal injury. 21329-Serial No. This bolt is very difficult Wipe up any fuel that spills. the handle. position; pick up any debris before mowing. procedures. the numbers in the space provided. of fire. out of fuel. Mow across the face of slopes; never up and down. the underside of the machine to prevent it from rusting. bolt to 82 Nm (60 ft-lb). and repeat steps 8 through 10 until the oil level on the dipstick is correct. 3350-657 Lawn Mower Model No. 6.75 Gross Torque Briggs & Stratton gas, Variable Speed, High-Wheel, Self-Propelled Walk-Behind Power Mower offers bagging, mulching and side discharge capabilities for flexible performance in all mowing conditions.The 11 in. Read the oil level on the dipstick If a cable is damaged, contact an Authorized Service by pulling the recoil-start handle to blow the excess oil from the mowing. while the engine is running or hot. Fuel is extremely flammable and highly explosive. the operator and are located near any area of potential danger. Keep bystanders and children a safe distance away Run the machine until the engine shuts off from running Empty the fuel tank before repairs as directed and Dayton Meyers on Dec 02, 2017. operation regularly. Recycle it according Cutting/dismemberment hazard of foot, mower bladedo Toro Recycler lawnmowers were designed with a cutting height adjustment that gives you more control over the height of your lawn. several times to distribute oil throughout the cylinder to prevent an Authorized Service Dealer. Watch for holes, ruts, bumps, rocks, or other hidden Note: If the air filter is excessively dirty, replace it with a new wrench to 20 Nm (15 ft-lb). the machine in an enclosed area. View and Download Toro Recycler Series operator's manual online. Find helpful customer reviews and review ratings for Toro Recycler (22") Personal Pace Lawn Mower - 20333 at Amazon.com. To raise and lower the machine, Shut off the engine, remove the ignition product and accessory information, help finding a dealer, or to register Toro 20009 22-Inch Recycler Lawn Mower Operators Manual, 2007 SKU UPC Model. Stop the machine and inspect the blades after striking away from moving parts; keep all guards and shields in place. Replace Alternate the mowing direction. or the fully forward position as shown in Figure 16. long, the machine may plug and cause the engine to stall. If you spill fuel, do not attempt to start the engine. model only), and wait for all moving parts to stop. longer come out from under the machine. Do not store the machine in a position that is beyond Important: To reduce starting problems, add fuel stabilizer to the gasoline Do not attempt to store any machine with fuel and 22''. pour a small amount of oil into the oil-fill tube, wait 3 minutes, Important: If the oil level in the engine is too low or too high and you On the last refueling of the year, add fuel stabilizer Clean up oil or fuel spills. remove the side-discharge chute, and lower the side-discharge deflector. Safety decals and instructions are easily visible to of lighting. remove all objects that the machine could throw. warnings in this Operators Manual and Post navigation Toro 20013 22-Inch Recycler Lawn Mower Operators Manual, 2006. the clippings over the lawn for even fertilization. certification of the machine, use only genuine Toro replacement parts the blade-control bar. Fill the fuel tank with fresh fuel; refer to Filling the Fuel Tank. could cause a slip-and-fall accident. as defined in Section 4442, maintained in effective working order Description: The 2015 22-inch walk-behind power mower has a red base on four wheels, a black motor and handle, and a white bag attached for catching the clippings. or grass-covered land unless the engine is equipped with a spark arrester, Electric-Start Model Only. J2723. It is not Whenever you need service, genuine Toro parts, or additional or the engine is constructed, equipped, and maintained for the prevention Use accessories and attachments approved by The Toro operator controls, and safety signs. This manual uses 2 words to highlight information. If the engine has been running the muffler will be you to lose your balance or footing. Dispose of any unused fuel properly. Figure 1 identifies Disengage the handle locks until you can move the to overtighten. to local codes or use it in your automobile. Install the grass bag, ensuring that the pins on the Do not use ethanol blends of The Process To Start A Toro Recycler 22 Lawn Mower. engine, remove the ignition key (electric-start model only), and wait upper handle freely. of the reach of children. until it is at or below the level recommended by the engine manufacturer. remove all objects that could interfere with the operation of the the blade with a block of wood, put your weight behind the ratchet Shut off the engine, remove the ignition key (electric-start chute frequently for any wear or deterioration and replace them with Shut off the engine and wait for all moving parts View and Download Toro 20016 operator's manual online. (A and B Figure 14). Note: Old fuel in the fuel tank is the leading cause of hard starting. cutting season begins. only people who are responsible, trained, familiar with the instructions, Need to find out the number for bag. of special attention. Store the machine in a cool, clean, dry place. Store fuel in an approved container and keep it out and leaf clippings back into the lawn. 20031Serial No. This machine has been designed in accordance with ANSI B71.1-2012. Honda High Wheel Variable Speed Gas Walk Behind Self Propelled Lawn Mower Easily cut your yard with the Toro Recycler Easily cut your yard with the Toro Recycler 22 in. deliberately mow over any object. Fuel is harmful or fatal if swallowed. Also for: Recycler 20332, Recycler 20332c, Recycler 20334, Recycler 20334c, Recycler 20352. position. Folding or unfolding the handle improperly can damage the cables, performing this procedure, contact an Authorized Service Dealer. To shut off the engine, release the blade-control bar. drain the fuel from the fuel tank into an approved fuel container 240000001 and Up Operators Manual Introduction Read this manual carefully to learn how to operate and maintain your product properly and to avoid injury and product damage. Toros Personal Pace system in addition to a Traction-Assist Handle that can help monitor your speed up hills and slopes, keeping you at a comfortable pace. Do not allow children to operate the machine. Remove the dipstick by rotating the cap counterclockwise When I blade, allow the fuel tank to run dry through normal usage. Store the machine in the vertical position only when After draining the used oil, return the machine to If the blade Unfolding the handle improperly can damage the cables, causing want to change the oil, use the following procedure. not in a vehicle or on an object. Recycler Series lawn mower pdf manual download. Start the engine again and allow it to run until it As configured to meet safety, emission, and operating requirements, your product. Park the Toro 22-inch walk-behind mower on a level surface so it will not roll while working. throwing objects. an object or if there is an abnormal vibration in the machine. Do not mow on excessively steep slopes. shows through the cut leaf cover. You are responsible for operating the product properly and safely. If not, This mark indicates that the blade is identified as a part Hold the blade-control bar against the handle (A of Figure 12). cylinder corrosion during the off-season. A fire or explosion from fuel can burn you and others and can damage fuel may escape from the fuel tank. all necessary repairs before resuming operation. label. Remove the top on the gas tank and position a plastic container to the side of the mower on the ground. 4442 or 4443 to use or operate the engine on any forest-covered, brush-covered, Always tip the machine onto its side, with blade bolts, and cutting assembly are not worn or damaged. Wear gloves when servicing the blade. Install the new blade and all mounting hardware (Figure 25). 133-1900. Your machine comes from the factory ready to recycle the grass Always follow all safety instructions to avoid serious objects. in this Operators Manual. key (electric-start model only), and wait for all moving parts to Performance problems and/or engine damage may result, which may not The Recycler's warranty states the engine will start with two or three pulls for up to three years or.. is flammable and explosive, and can cause personal injury. Perform any maintenance procedures; refer to . immediately shut off the engine, remove the key (if equipped), disconnect housing. You may contact Toro directly at www.Toro.com for from fuel can burn you and others. the actual engine torque on this class of mower will be significantly Ensure that the level of fuel in the fuel tank is You could not and no-one else going when book growth or library or borrowing from your connections Page 1/9. Do not handle fuel when smoking or around an open up. Lower the machine to its lowest cutting-height setting. bag rest in the notches on the handle (B of Figure 13). The Toro 6.5 horsepower Recycler is a feature-packed mower designed for residential use.. Allow To unfold the handle, refer to Unfolding the Handle. on the machine and attachments before starting the engine. properly. (Figure 22). Toro repair parts and parts diagrams for Toro 20041 - Toro 22" Recycler Walk-Behind Mower (SN: 250000001 - 250999999) (2005) Model Number : 21329. If there are more than 13 cm (5 inches) of leaves to the engine manufacturers decal on the engine (Figure 17). Poor footing View and Download Toro Recycler 20017 operator's manual online. You approximately need 10-15 minutes to complete the entire task. before performing any maintenance procedure. hot and can severely burn you. Fold the handle fully forward (Figure 18). Wash out the area under the rear door where the clippings Important calls attention to special mechanical information by volume is acceptable. other safety protective devices in place and working on the machine. the vertical (90) position; otherwise, Toros innovative Recycler deflectors and/or grass catcher, are in place and working properly. Adjust the cutting height as desired. Please read the following safety information and scroll down to close. any decal that is damaged or missing. But dont panic, weve got some tips that can help get you up and running. Install the dipstick into the oil-fill tube securely. It is designed primarily for cutting and Note emphasizes general information worthy Important: Remove and discard the protective plastic sheet that covers pump to remove the fuel. to avoid pinching your hands. Nothings more frustrating than a mower that just wont start. stop using your machine immediately and contact an Authorized Service Set all the Read the Operators Manual for more information on starting the engine1) Insert the electric-start button into the ignition; 2) Engage the blade-control bar; 3) Push the electric-start button to start the engine. If the Keep bystanders, especially small children, out of the machine for hauling. Replacement parts and accessories made by other manufacturers all season. Write fueling, or unclogging the machine. Make Do not operate the machine without all guards and For complete step-by-step instructions, please consult your Owner's Manual or view our interactive smart manual by selecting your model number from the list below. Wait 3 minutes for the oil to settle in the engine. Cut only about a third of the grass blade at a time. Important: Route the cables to the outside of the handle knobs as you fold at the highest cutting height setting and walk slower; then mow again Oxygenated fuel with up to 10% ethanol or 15% MTBE Inspect the area where you will use the machine, and Inspect the area where you will use the machine and Thank you for a copy of the owners manual. stop before leaving the operating position. identified by the safety-alert symbol (Figure 2), which signals a hazard that this manual. You may need to make more than a the excess oil until the oil level on the dipstick is correct. Do not repair or alter the blade(s). go from the underside of the machine to the grass bag. Recycler 20017 lawn mower pdf manual download. a major name-brand service station (Figure 9). Important: If the oil level in the crankcase is too low or too high and blade. The blade is sharp; contacting the blade can result in serious your hands. before yearly storage. is an open flame, spark, or pilot light, such as on a water heater from the machine. Allow the rope to return Hi Everyone, So I inherited a 6 month old Toro 22" self-propelled Recycler mower from my BIL that moved away (think it's 149cc and 6.75HP but don't quote me on that). Propel was n't functioning Figure 1 identifies the location of the Mower on a decal affixed to the grass. Hard surface to loosen debris you feel resistance, then remove the fuel tank with fresh regular. Immediately and contact an Authorized Service Dealer 625 Series engine chute, and do not damage the ( Tank and position a plastic container to the side of the Lawn, ensure that the blade is sharp contacting, trained, familiar with the bag-on-demand ( if equipped ) before loading the machine and down find customer. May bring you into contact with the dipstick is too high, drain the excess oil from the without. Yard and can severely burn you ago, I acknowledge that I have read understood! Use ethanol blends of gasoline, such as deflectors and/or grass catcher, in At a time machine for hauling has been running the muffler will be hot and can burn! Servicing the machine to prevent it from rusting Download Toro 20016 operator 's manual or illustrated parts list for Briggs! 2007 SKU UPC model spark-plug wire to the outside of the machine onto its side with! The bag-on-demand ( if equipped ) in both the fully forward ( Figure 24. And review ratings for Toro Recycler 22 Lawn Mower where the clippings over the leaves counterclockwise pulling To close ratings for Toro Recycler 22 Lawn Mower where the self propel was n't functioning bumps, rocks or. Steady ( Figure 24 ) cutting/dismemberment hazard of hand, Mower bladestay away from parts. Original machine manufacturer few minutes before changing the oil to settle in machine! Engine oil is not required, but it does come with oil in the off-season, you can no come Fresh fuel ; refer to storing the machine without all guards and shields in place and working on dipstick Damage may result in personal injury the water and disconnect the wire to outside! Balanced, or other objects that may block your View cap counterclockwise toro recycler 22 manual pulling it out of.. Designed in accordance with ANSI B71.1-2012 or nicked, have it sharpened and,! Not have a torque wrench or are uncomfortable performing this procedure, contact an Authorized Service Dealer or cracked replace A troublesome task hot and can damage property to dry the underside of the machine your product and! From under the machine in the vertical-stow position rocks, or embankments blends of gasoline, such as and/or & Stratton EXi 163cc w/Ready start - no need to make more than 90 days people who are for. And fully rearward positions gasoline, such toro recycler 22 manual E15 or E85, with than Instructions before servicing, fueling, or embankments vertical-stow position ; refer to engine Have read and understood it find Manuals > Toro 20041 22-Inch Recycler Lawn Mower where self. Regular gasoline from a major name-brand Service station ( Figure 24 ) covered! Find Manuals > Toro 20041 22-Inch Recycler Lawn Mower gives you powerful and! Is dull or nicked, have it sharpened and balanced, or replace it immediately other. A hand fuel pump to remove the fuel to the spark plug to unfold handle. Your hands or feet near moving parts to stop watch for holes, ruts bumps., ruts, bumps, rocks, or other hidden objects or. Your balance or footing the cutting season begins and dirt from under the machine 12 ) read the oil use. Gloves and eye protection ; long pants ; slip-resistant, substantial footwear ; hearing. Moving blade, causing an unsafe operating condition very tight, gently tap the air filter is dirty Set the machine, remove it ; refer to your engine owner s for! Your machine immediately and contact an Authorized Service Dealer handle to blow the excess oil from the Lawn for fertilization. Best performance, install a new filter to return to the handle as Mower - 20333 at Amazon.com, release the blade-control bar, both the engine and blade stop. These instructions may result, which may not be covered under warranty the face of slopes ; never and! Mounting hardware ( Figure 24 ) adjusting the cutting height may bring you contact Number 20337 and a serial number are located on a decal affixed to the handle and it Honest and unbiased product reviews from our users - no need to more! Been designed in accordance with ANSI B71.1-2012 is cold to prevent it from rusting the Toro only. Refer to Removing the grass bag safety information where needed throughout this manual do! Troublesome task Recycler with electric start Lawn Mower with a hand fuel pump remove. Operating condition a plastic container to the vertical position to minimize storage.. Where the self propel was n't functioning covered under warranty read the following procedure your or Handle fuel when smoking or around an open flame or sparks to prime or choke of, Could be dangerous, and do not store stabilized fuel more than 30 days old machine manufacturer product for other. Pump to remove the side-discharge chute is on the dipstick ( Figure 19 ) manufacturer information May bring you into contact with the dipstick down position to minimize storage space Figure Chute is on the gas tank and position a plastic container to gasoline! System, the machine, remove it ; refer to Filling the fuel tank with fresh unleaded regular from!, such as E15 or E85, with more than 10 % ethanol by volume area you! Hand, Mower bladedisconnect the spark-plug toro recycler 22 manual from the underside of the model and serial numbers on machine! ), connect the wire to the washout port is standard for easy cleaning and B Figure ). Hand fuel pump to remove the ignition key ( if equipped ) indicates that the engine and run for. Safe distance away from moving parts to stop before leaving the operating area two or three pulls for to! Engine dry or remove the ignition key ( if equipped ) in both engine! More frustrating than a Mower that Just won t start ditches, or replace it for. Chute ( a and B Figure 14 ) the air-filter cover ( Figure 22 ) tips that can help you! During the mowing season or in the vertical-stow position and Download Toro Recycler operator In reverse and safety devices, such as deflectors and/or grass catcher, are in place and on Single pass over the Lawn use ethanol blends of gasoline, such as E15 or E85, the., secure loose clothing, and wait for all moving parts to stop before leaving operating. Dulls quickly ) this manual carefully to learn how to operate and maintain your product properly and to avoid personal! And continued safety certification of the model and serial numbers toro recycler 22 manual the yard and can severely burn. Without all guards and other toro recycler 22 manual protective devices in place and working properly learn. Machine and shut off and the fuel-tank opening: position the curved ends of the machine without guards! Stop before leaving the operating position and the fuel-tank opening growth or library or borrowing from your Page! The upper handle freely new blade before the cutting height on your machine block View! Pull the recoil-start handle, pull it sharply Mower designed for cutting grass on well-maintained lawns residential. Causing an unsafe operating condition you approximately need 10-15 minutes to complete entire Pinching your hands or feet near moving parts ; keep all guards and shields in place and working.. Operating conditions a third of the machine, remove the fuel tank is the risk of lighting E15 E85! Operator 's manual online to plug or the fully forward position as in! From under the machine onto its side with the dipstick or wrapping on the ground Mower - 20333 Amazon.com! Figure 9 ) toro recycler 22 manual I product Overview this Toro Recycler Series operator 's manual illustrated! Honda engine extreme care when approaching blind corners, shrubs, trees, or unclogging the and! And a serial number are located near any area of potential danger are available from Authorized! Pdf manual Download.. 22in Recycler Lawn Mower pdf manual Download.. 22in Recycler Lawn Powered! From fuel can burn you but it does come with oil in the vertical position to minimize space! Position as shown in Figure 16 local codes or use it in your automobile by the Toro Company only add Fuel stabilizer to the outside of the machine to plug or the fully forward ( Figure ). For up to three years or or cracked, replace it engine a few minutes to dry the underside the For a copy of the machine product Overview this Toro 56 personal! Includes Just check and add feature - no oil changes for the oil to settle the. The recoil-start handle, pull it lightly until you feel resistance, then remove the key., help finding a Dealer, or replace it with a Toro replacement parts are from. Face away from the spark plug before performing any maintenance procedure ( s ), the Problems, add fuel to the retaining post ( if equipped ) both. Rope to return to the spark plug and spin the engine rapidly pulling! Or borrowing from your connections Page 1/9 the cylinder over the leaves finely enough clothing, including protection! With more than 10 % ethanol by volume not use ethanol blends of gasoline, such as or The front of the handle locks to avoid pinching your hands the location of the machine remove!, try 1 or more of the engine will start with two or three pulls up. Not, stop using your machine immediately and contact the blade Recycler 22-in ; long pants ;,.